Poulan 184581 Manuel d'utilisateur

OWNER'S MANUALMODEL:PD18H42STALAWN TRACTOR ALWAYS WEAR EYE PROTECTION DURING OPERATION WARNING:Read this Owner's Man u al and foll

10OPERATIONKNOW YOUR TRACTORREAD THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTORCompare the illustrations with your tractor to

11OPERATIONThe operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye dam age. Always wear safe

12OPERATIONTO OPERATE ON HILLS WARNING: Do not drive up or down hills with slopes greater than 15° and do not drive across any slope.• Choose th

13OPERATIONTO START ENGINE (See Fig. 5)When starting the engine for the fi rst time or if the engine has run out of fuel, it will take extra cranking t

14FIG. 10 MOWING TIPS• Mower should be properly leveled for best mowing per-formance. See “TO LEVEL MOWER HOUSING” in the Service and Adjustment

15MULCHING MOWING TIPSIMPORTANT: FOR BEST PERFORMANCE, KEEP MOWER HOUSING FREE OF BUILT-UP GRASS AND TRASH. CLEAN AFTER EACH USE.• The spe cia

16MAINTENANCEBEFORE EACH USETRACT0RInspect Muffler/Spark ArresterLubrication ChartCheck Brake OperationClean Air FilterChange Engine Oil (with oil fil

17MAINTENANCEBLADE REMOVAL (See Fig. 12)• Raise mower to highest position to allow access to blades.• Remove blade bolt, lock washer and fl at

18CLEAN AIR INTAKE/COOLING AREASTo insure proper cooling, make sure the grass screen, cooling fi ns, and other external surfaces of the engine are kept

19MAINTENANCEMUFFLER Inspect and replace corroded muffl er and spark arrester (if equipped) as it could create a fi re hazard and/or dam-age.SPARK PLU

2DO NOT:• Do not turn on slopes unless necessary, and then, turn slowly and gradually downhill, if possible.• Do not mow near drop-offs, ditch

20SERVICE AND ADJUSTMENTSWARNING: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SER VICE OR AD JUST -MENTS• Depress clutch/brake pedal fully and set

21SERVICE AND ADJUSTMENTSNUT "E""D""D"MANDRELFIG. 21NUT "F"FRONT LINKSFIG. 22FRONT-TO-BACK ADJUSTMENT (See Fig

22SERVICE AND ADJUSTMENTSFIG. 23TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 23)The mower blade drive belt may be replaced without tools. Park the tra

23SERVICE AND ADJUSTMENTSTO REMOVE WHEEL FOR REPAIRS (See Fig. 27)• Block up axle securely.• Remove axle cover, retaining ring and washer

24TO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 31)• Raise hood.• Unsnap headlight wire connector.• Stand in front of tractor. Grasp h

25SERVICE AND ADJUSTMENTSCABLECLAMPSCREWSPEED CONTROLBRACKETIDLE FUELADJUSTINGNEEDLEIDLE SPEEDADJUSTING SCREWTHROTTLELEVERFIG. 32FIG. 33ENGINEMaintena

26STORAGEImmediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more.WARNING: Never

27PROBLEM CAUSE CORRECTION TROUBLESHOOTING POINTSWill not start 1. Out of fuel.

28PROBLEM CAUSE CORRECTION TROUBLESHOOTING POINTSEngine continues to run 1. Faulty operator-safety presen

29REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93SCHEMATIC8787A858630RELAYWIRING INSULATED CLIPSNOTE: IF WIRING INSULATED CL

3WARNING: In order to prevent ac- ci den tal starting when setting up, trans port ing, ad just ing or making re-pairs, al ways dis con nect spark pl

30REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93ELECTRICAL2829262442432727254127274033309082127161652D.C. AMPERES45818181

31REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93ELECTRICAL1 163465 Battery 12 Volt 25 Amp2 747604

32REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93CHASSIS AND ENCLOSURES26255864208132081113292082092095520733314233314214537

33REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93CHASSIS AND ENCLOSURES1 174619 Chassis2 176554

34REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93DRIVE66292832305232593861415335553662353622393416177 7730525664652126311670

35REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93DRIVEKEY PARTNO. NO. DESCRIPTION KEY PARTNO. N

36REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93STEERING ASSEMBLY5543436438104032118687464686872988711743912141423736373812

37REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93STEERING ASSEMBLY1 180656 Wheel Steering 2 184706

38REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93ENGINE21OPTIONAL EQUIPMENTSpark Arrester29105105316101774801011323451438444

39REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93ENGINENOTE: All component dimensions given in U.S. inches1 inch = 25.4 mm1

4GASOLINE CAPACITY 2.0 GALLONSAND TYPE: UNLEADED REGULAROIL TYPE (API-SF-SJ): SAE 10W30 (above 32°F) SAE 5W-30

40REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93SEAT ASSEMBLYKEY PART NO. NO. DESCRIPTION

41WHEELS & TIRESKEY PART NO. NO. DESCRIPTION1 59192 Cap Valve Tire 2 65139

42REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93MOWER LIFT36152016171820201520456231654737414038121131323132191913131313232

43REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93MOWER LIFT1 184432 Plunger Asm.2 159476

44REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93MOWER DECK15141311109816683031323314614814515045144147147142149142545253555

45REPAIR PARTSTRACTOR - - MODEL NUMBER PD18H42STA, PRODUCT NO. 954 56 94-93MOWER DECK1 182032X421 Mower Deck Assembly, 42"2 7214

46LIMITED WARRANTYThe Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi-als an

4715 DEGREES MAX.FOLD ALONG DOTTED LINETHIS IS A 15 DEGREE SLOPEONLY RIDE UP AND DOWN HILL,NOT ACROSS HILLSUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE

Your POULAN PRO product has been expertly en gi neered and carefully manu fac tured to rigid quality stan dards. As with all mechanical products

5UNASSEMBLED PARTS(1) Large Flat WasherSteering Wheel InsertSteering SleeveSteering Wheel(1) Knob(1) Washer 17/32 x 1-3/16 x 12 GaugeSeat(2) Mulch Bl

6HOW TO SET UP YOUR TRACTORINSTALL SEAT (See Fig. 2)Adjust seat before tightening adjustment knob.• Remove adjustment knob and fl at washer

7ASSEMBLYFIG. 2SEAT PANSHOULDER BOLTADJUSTMENT KNOBFLAT WASHERSEATFIG. 3SEAT PANLABELCHECK BATTERY (See Fig. 3)• Lift seat pan to raised position

8ASSEMBLY✓CHE CKLISTBEFORE YOU OPERATE AND ENJOY YOUR NEW TRAC- TOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM TH

9OPERATIONThese symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean-ing.DANGER, KEEP HANDS