Poulan 184564 Manuel d'utilisateur

OWNER'S MANUALMODEL:PD1842STALAWN TRACTOR ALWAYS WEAR EYE PROTECTION DURING OPERATION WARNING:Read this Owner's Man u al and follo

10OPERATIONKNOW YOUR TRACTORREAD THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTORCompare the illustrations with your tractor to

11OPERATIONThe operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye dam age. Always wear safe

12OPERATIONTO OPERATE MOWER (See Fig. 8)Your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to leave the s

13OPERATIONADD GASOLINE • Fill fuel tank to bottom of fi ller neck. Do not overfi ll. Use fresh, clean, regular un lead ed gasoline with a minimum

14MULCHING MOWING TIPSIMPORTANT: FOR BEST PERFORMANCE, KEEP MOWER HOUSING FREE OF BUILT-UP GRASS AND TRASH. CLEAN AFTER EACH USE.• The spe cia

15MAINTENANCEBEFORE EACH USETRACT0RInspect Muffler/Spark ArresterLubrication ChartCheck Brake OperationClean Air FilterChange Engine Oil (with oil fil

16MAINTENANCEBLADE REMOVAL (See Fig. 11)• Raise mower to highest position to allow access to blades.• Remove blade bolt, lock washer and fl at

17MAINTENANCEV-BELTSCheck V-belts for deterioration and wear after 100 hours of operation and replace if necessary. The belts are not ad just able. Re

18MAINTENANCEMUFFLER Inspect and replace corroded muffl er and spark arrester (if equipped) as it could create a fi re hazard and/or dam-age.SPARK PLU

19SERVICE AND ADJUSTMENTSWARNING: TO AVOID SE RI OUS IN JU RY, BEFORE PERFORMING ANY SERVICE OR ADJUST-MENTS:• Depress clutch/brake pedal fully and

2DO NOT:• Do not turn on slopes unless necessary, and then, turn slowly and gradually downhill, if possible.• Do not mow near drop-offs, ditch

20SERVICE AND ADJUSTMENTSNUT "E""D""D"MANDRELFIG. 20NUT "F"FRONT LINKSFIG. 21FRONT-TO-BACK ADJUSTMENT (See Fig

21SERVICE AND ADJUSTMENTSFIG. 22TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 22)The mower blade drive belt may be replaced without tools. Park the tra

22TO START ENGINE WITH A WEAK BATTERY (See Fig. 27) WARNING: Lead-acid batteries gen- er ate ex plo sive gases. Keep sparks, fl ame and smoking ma t

23REPLACING BATTERY (See Figs. 28 and 29)WARNING: Do not short battery ter- mi nals by allowing a wrench or any other object to contact both terminal

24SERVICE AND ADJUSTMENTSCABLECLAMPSCREWSPEED CONTROLBRACKETTHROTTLELEVERENGINETO AD JUST THROTTLE CON TROL CABLE (See Fig. 31)The throttle control h

25STORAGEImmediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more.WARNING: Never

26PROBLEM CAUSE CORRECTION TROUBLESHOOTING POINTSWill not start 1. Out of fuel.

27PROBLEM CAUSE CORRECTION TROUBLESHOOTING POINTSEngine continues to run 1. Faulty operator-safety presen

28NOTES

29REPAIR PARTSTRACTOR - - MODEL NUMBER PD1842STA, PRODUCT NO. 954 56 94-86SCHEMATIC8787A858630RELAYWIRING INSULATED CLIPSNOTE: IF WIRING INSULATED CLI

3WARNING: In order to prevent ac- ci den tal starting when setting up, trans port ing, ad just ing or making re-pairs, al ways dis con nect spark pl

30REPAIR PARTSTRACTOR - - MODEL NUMBER PD1842STA, PRODUCT NO. 954 56 94-86ELECTRICAL28292624424327272541272740333090821271616522221D.C. AMPERES4581818

31REPAIR PARTSTRACTOR - - MODEL NUMBER PD1842STA, PRODUCT NO. 954 56 94-86ELECTRICAL1 163465 Battery 12 Volt 25 Amp2 7476

32REPAIR PARTSTRACTOR - - MODEL NUMBER PD1842STA, PRODUCT NO. 954 56 94-86CHASSIS AND ENCLOSURES262558642081320811132920820920955207333142333142145373

33REPAIR PARTSTRACTOR - - MODEL NUMBER PD1842STA, PRODUCT NO. 954 56 94-86CHASSIS AND ENCLOSURES1 174619 Chassis2 176554

34REPAIR PARTSTRACTOR - - MODEL NUMBER PD1842STA, PRODUCT NO. 954 56 94-86DRIVE29281121441383957517475787677125192425335343736356236592125577612227266

35REPAIR PARTSTRACTOR - - MODEL NUMBER PD1842STA, PRODUCT NO. 954 56 94-86DRIVEKEY PARTNO. NO. DESCRIPTION KEY PARTNO.

36REPAIR PARTSTRACTOR - - MODEL NUMBER PD1842STA, PRODUCT NO. 954 56 94-86STEERING ASSEMBLY55434364381040321186874646868729887117439121414237363738123

37REPAIR PARTSTRACTOR - - MODEL NUMBER PD1842STA, PRODUCT NO. 954 56 94-86STEERING ASSEMBLY1 180656 Wheel Steering 2 1847

38NOTE: All component dimensions given in U.S. inches1 inch = 25.4 mm1 170805 Control Throt /Ch Flag2 17720408 S

39REPAIR PARTSTRACTOR - - MODEL NUMBER PD1842STA, PRODUCT NO. 954 56 94-86SEAT ASSEMBLYKEY PART NO. NO. DESCRI

4GASOLINE CAPACITY 2.0 GALLONSAND TYPE: UNLEADED REGULAROIL TYPE (API-SF-SJ): SAE 10W30 (above 32°F) SAE 5W-30

40WHEELS & TIRESKEY PART NO. NO. DESCRIPTION1 59192 Cap Valve Tire 2 65139

41REPAIR PARTSTRACTOR - - MODEL NUMBER PD1842STA, PRODUCT NO. 954 56 94-86MOWER LIFT361520161718202015204562316547374140381211313231321919131313132324

42REPAIR PARTSTRACTOR - - MODEL NUMBER PD1842STA, PRODUCT NO. 954 56 94-86MOWER DECK151413111098166830313233146148145150451441471471421491425452535556

43REPAIR PARTSTRACTOR - - MODEL NUMBER PD1842STA, PRODUCT NO. 954 56 94-86MOWER DECK1 182032X421 Mower Deck Assembly, 42"2 72

44NOTES

45LIMITED WARRANTYThe Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi-als an

46TECUMSEH®Issued January 1980Revised January 1991TECUMSEH®SERVICEPOLICYWARRANTYLIMITED WARRANTIESFOR NEW PEERLESS GEAR POWER TRAIN COMPONENTSA. Prod

4715 DEGREES MAX.FOLD ALONG DOTTED LINETHIS IS A 15 DEGREE SLOPEONLY RIDE UP AND DOWN HILL,NOT ACROSS HILLSUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE

Your POULAN PRO product has been expertly en gi neered and carefully manu fac tured to rigid quality stan dards. As with all mechanical products

5UNASSEMBLED PARTS(1) Large Flat WasherSteering Wheel InsertSteering SleeveSteering Wheel(1) Knob(1) Washer 17/32 x 1-3/16 x 12 GaugeSeat(2) Mulch Bl

6HOW TO SET UP YOUR TRACTORINSTALL SEAT (See Fig. 2)Adjust seat before tightening adjustment knob.• Remove adjustment knob and fl at washer

7ASSEMBLYFIG. 2SEAT PANSHOULDER BOLTADJUSTMENT KNOBFLAT WASHERSEATFIG. 3SEAT PANLABELCHECK BATTERY (See Fig. 3)• Lift seat pan to raised position

8ASSEMBLYFIG. 4BTO CONVERT TO BAGGING OR DISCHARGINGNOTE: The mulcher blades will dis charge and bag grass, but for best bagging and discharging insta

9OPERATIONThese symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean-ing.DANGER, KEEP HANDS