OWNER'S MANUALMODEL:DPR22H46STALAWN TRACTORAlways Wear Eye Protection During Operation WARNING:Read this Owner's Manual andfollow all W
10CHECK TIRE PRESSUREThe tires on your tractor were overinflated at the factory forshipping purposes. Correct tire pressure is important forbest cutt
11These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning.BATTERY CAUTION ORWARNINGRE
12OPERATIONKNOW YOUR TRACTORREAD THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTORCompare the illustrations with your tractor to
13OPERATIONCAUTION: Always stop tractor com-pletely, as described above, before leav-ing the operator's position; to emptygrass catcher, etc.TO
14OPERATIONLOWPOSITIONTO OPERATE MOWER (See Fig. 12)Your tractor is equipped with an operator presence sensingswitch. Any attempt by the operator to
15OPERATIONPURGE TRANSMISSIONCAUTION: Never engage or disengagefreewheel lever while the engine isrunning.To ensure proper operation and performance,
16OPERATIONMULCHING MOWING TIPSIMPORTANT: FOR BEST PERFORMANCE, KEEPMOWER HOUSING FREE OF BUILT-UP GRASSAND TRASH. CLEAN AFTER EACH USE.• The specia
17LUBRICATION CHARTFRONT WHEELBEARING ZERKFRONT WHEELBEARING ZERKENGINESPINDLE ZERKSPINDLE ZERKGENERAL PURPOSE GREASEREFER TO CUSTOMER RESPONSIBILIT
18CUSTOMER RESPONSIBILITIESTRACTORAlways observe safety rules when performing any mainte-nance.BRAKE OPERATIONIf tractor requires more than six (6) fe
19CUSTOMER RESPONSIBILITIESFIG. 19CLEAN AIR SCREENAir screen must be kept free of dirt and chaff to preventengine damage from overheating. Clean with
2I. GENERAL OPERATION• Read, understand, and follow all instructions in themanual and on the machine before starting.• Only allow responsible adults,
20CUSTOMER RESPONSIBILITIESMUFFLERInspect and replace corroded muffler and spark arrester (ifequipped) as it could create a fire hazard and/or damage.
21BOTTOM EDGEOF MOWER TOGROUNDBOTTOM EDGEOF MOWER TOGROUNDAAGROUND LINEFIG. 23FIG. 24LIFT LINKADJUSTMENT NUTSUSPENSION ARMRETAINER SPRINGSLIFTLINKSFIG
22FRONT-TO-BACK ADJUSTMENT (See Figs. 25 and 26)IMPORTANT: DECK MUST BE LEVEL SIDE-TO-SIDE. IFTHE FOLLOWING FRONT-TO-BACK ADJUSTMENT ISNECESSARY, BE
23TRANSAXLE MOTION CONTROL LEVERNEUTRAL ADJUSTMENT (See Fig. 31)The motion control lever has been preset at the factory andadjustment should not be n
24TO REMOVE WHEEL FOR REPAIRS(See Fig. 32)• Block up axle securely.• Remove axle cover, retaining ring and washers to allowwheel removal (rear wheel c
25SERVICE AND ADJUSTMENTSFIG. 34HEXBOLTKEPS NUTPOSITIVE(RED)CABLENEGATIVE(BLACK)CABLETERMINALGUARDTERMINALACCESSDOORTO REPLACE HEADLIGHT BULB• Raise h
26SERVICE AND ADJUSTMENTSCLAMP SCREWFIG. 37FIG. 36SWIVELCLAMPSCREWSTOPENGINETO ADJUST THROTTLE CONTROL CABLE(See Fig. 36)The throttle control has bee
27STORAGEImmediately prepare your tractor for storage at the end ofthe season or if the tractor will not be used for 30 days ormore.CAUTION: Never st
28TROUBLESHOOTING POINTSWill not start 1. Out of fuel. 1. Fill fuel tank.2. Engine not “CHOKED” properly. 2. See “TO START ENGINE” in Operation sectio
29TROUBLESHOOTING POINTSEngine continues to run 1. Faulty operator-safety presence control system. 1. Check wiring, switches and connections. If n
3• Be sure the area is clear of other people before mowing.Stop machine if anyone enters the area.• Never carry passengers or children even with the b
30SERVICE NOTES
31BATTERYFUSEREDREDREDREDBLACKBLACKBLACKBLACKBLACKBLACKBLACKIGNITIONUNITSPARKPLUGS GAP(2 PLUGS ONTWIN CYL. ENGINES)NON-REMOVABLECONNECTIONSREMOVABLECO
32REPAIR PARTSTRACTOR - MODEL NUMBER DPR22H46STAELECTRICAL282926244243251827274033305022217981D.C. AMPERES45121211108212755521616
33KEY PARTNO. NO. DESCRIPTIONNOTE: All component dimensions given in U.S. inches.1 inch = 25.4 mm.1 163465 Battery2 74760412 Bolt Hex Hd 1/4-20 UNC X
34REPAIR PARTSTRACTOR - MODEL NUMBER DPR22H46STACHASSIS AND ENCLOSURES642091587430159 209 133311915715660144252626102614425266033314233314214360172914
35KEY PARTNO. NO. DESCRIPTIONNOTE: All component dimensions given in U.S. inches1 inch = 25.4 mm1 169830 Chassis2 176554 Drawbar3 17060612 Screw 3/8-
36REPAIR PARTSTRACTOR - MODEL NUMBER DPR22H46STADRIVE292832305232596153355536623536223416177 773052579626251924262676787574272615375151899027514815120
37KEY PARTNO. NO. DESCRIPTIONKEY PARTNO. NO. DESCRIPTIONNOTE: All component dimensions give in U.S. inches.1 inch = 25.4 mmREPAIR PARTSTRACTOR - MODEL
38REPAIR PARTSTRACTOR - MODEL NUMBER DPR22H46STASTEERING ASSEMBLY1158758743436438403286464686233353468676767136568152929821038127213736374173428871291
39KEY PARTNO. NO. DESCRIPTIONNOTE: All component dimensions given in U.S. inches.1 inch = 25.4 mm.REPAIR PARTSTRACTOR - MODEL NUMBER DPR22H46STASTEER
4PRODUCT SPECIFICATIONS GASOLINE CAPACITY 3.5 GALLONSAND TYPE: UNLEADED REGULAROIL TYPE (API-SF-SJ): SAE 30 (above 32°F)SAE 5W-30 (below 32°F)O
40REPAIR PARTSTRACTOR - MODEL NUMBER DPR22H46STAENGINE1021OPTIONAL EQUIPMENTSpark Arrester291062 6572132625483231343337333917161738123451438KEY PARTNO
41KEY PARTNO. NO. DESCRIPTIONKEY PARTNO. NO. DESCRIPTION1 171684 Seat2 140551 Bracket Pivot Seat 8 7203 71110616 Bolt Fin Hex 3/8-16 Unc x 14 19131610
42103169KEY PARTNO. NO. DESCRIPTIONKEY PARTNO. NO. DESCRIPTION1 59192 Cap Valve Tire2 65139 Stem Valve3 170455 Tire F T 15 X 6 0 - 6 Service4 59904 Tu
43REPAIR PARTSTRACTOR - MODEL NUMBER DPR22H46STAMOWER LIFT361520161718202015204562316547823242527282930502637414038121131323132191913131313491 159461
44REPAIR PARTSTRACTOR - MODEL NUMBER DPR22H46STAMOWER DECK57561181161195117464533494142493637434046455044333030322120181821343112741424435504012672523
45KEY PARTNO. NO. DESCRIPTIONKEY PARTNO. NO. DESCRIPTIONNOTE: All component dimensions given in U.S. inches1 inch = 25.4 mm1 156833X421 Deck Asm., Mo
46LIMITED WARRANTYThe Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects inmaterials and
4715° MAX.SIGHT AND HOLD THIS LEVEL WITHSKY LINE OR TREE.CUT OUT ON DOTTED LINESTHIS IS A 15° SLOPESIGHTING GUIDEONLY RIDE UP AND DOWN HILL,NOT ACROSS
Your POULAN PRO product has been expertly engineered and carefully manufactured to rigidquality standards. As with all mechanical products, some
5UNASSEMBLED PARTSMower(3) Retainer Springs (double loop)(4) Retainer Springs (single loop)(2) Front Link AssembliesGauge Wheels(4) Washers 3/8 x 3/
6Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. Toensure safe and proper op
7FIG. 4NOSE ROLLER“B”BRACKETTABWASHERTABHOLELOCK NUT“A” BRACKETTABHEXBOLTTO ATTACH NOSE ROLLER (See Fig. 4)• Position brackets, 17/32 x 7/8 x 16 gauge
8ASSEMBLE GAUGE WHEELS TO MOWERDECK (See Fig. 5)The gauge wheels are designed to keep the mower deck inproper position when operating mower. Be sure t
9FIG. 8ANTI-SWAY BARDOUBLE LOOPRETAINER SPRINGGAUGEWHEELIDLER PULLEYCHASSISBRACKETDOUBLE LOOP RETAINERSPRING (Outward pointing deck pins)SUSPENSIONARM
Commentaires sur ces manuels